Not yet Run

Print Quote Print RO Print Invoice

Images

Jobs

Start Date	Description	Technician	Amount
2021-03-16	A. TRANSMISSION - DIESEL - DODGE TRANSMISSION 47RE/48RE COMPLETE STOCK RE-BUILD WITH RELIABILITY UPGRADES. ALSO INCLUDED IN THIS BUILD IS TO REMOVE THE ONE WAY CHECK VALVE IN ORDER TO ENSURE CONSTANT FLOW THROUGH THE COOLER. THIS BUILD INCLUDES A NEW VALVE BODY (COMES WITH NEW GOVERNER PRESSURE SENSOR AND TRANSDUCER). THIS BUILD PRICE IS FOR WEARABLE ITEMS AND UPGRADED PARTS COMMON ON MOST BUILDS HARD PART DAMAGE WILL REQUIRE ADDITIONAL COSTS THAT CAN ONLY BE DETERMINED ONCE TRANSMISSION IS DIS ASSEMBLED. - TECHNICIAN NOTES, ONCE DISASSEMBLED WE FOUND THE REVERSE BAND WAS STUCK ON AND CAUSED EXCESSIVE DAMAGE TO THE REVERSE DRUM. THE REVERSE DRUM IS CONSIDERED A HARD PART AND IS NOT TYPICALLY REPLACED AS PART OF OUR NORMAL BULD. TECHNICIAN ALSO RECOMMENDS REPLACING THE REVERSE SERVO DUE TO THE POSSIBLILITY OF DAMAGE.	LUKE HARRISON	$3,029.48
2021-03-16	B. TRANSMISSION - *****SPECIAL INSTRUCTION FOR RE BUILDING TRANSMISSIONS. CATASTROPHIC TRANSMISSION FAILURE CAN CAUSE EXCESSIVE METAL AND/OR DEBRIS TO ENTER THE TRANSMISSIONS COOLING SYSTEM, IF EXCESSIVE METAL IS FOUND IN THE TRANSMISSIONS FLUID THE TECHNICIAN MAY REQUIRE THE REPLACEMENT OF RADIATORS AND/OR TRANSMISSION COOLERS AT AN ADDITIONAL COST TO ENSURE METAL WILL NOT ENTER THE NEW TRANSMISSION. THE PRICE FOR THE TRANSMISSION RE BUILD WILL INCLUDE FLUSHING THESE COMPONENTS IF EXCESSIVE METAL IS NOT FOUND. TECHNICIAN WILL INSPECT TRANSMISSION LINES TO ENSURE THEY ARE IN PROPER OPERATING CONDITION AND FREE FROM CRACKING OR LEAKS, ANY TRANSMISSION LINE OR COMPONENT THAT IS LEAKING WILL BE REQUIRED TO BE REPAIRED IN ORDER TO UPHOLD OUR WARRANTY. CUSTOMER IS REQUIRED TO RETURN FOR AN INITIAL BREAK IN RE CHECK AFTER 1,000 MILES HAS BEEN PUT ON THE TRANSMISSION. THE RE CHECK WILL VERIFY BREAK IN, CHECK FLUID LEVEL, TEST DRIVE AND MONITOR SHIFT POINTS, VERIFY THERE IS NO LEAKS, AND ENSURE THE TRANSMISSION IS FREE FROM ANY DEFECTS. OUR RECOMMENDED SERVICE INTERVAL FOR OUR TRANSMISSION BUILDS IS EVERY 15,000 MILES AND IT MUST BE SERVICED OR FLUSHED IN ORDER TO UPHOLD WARRANTY WITH RECEIPT OR INVOICE PROOF TO VERIFY. TRANSMISSION TEMPERATURE MUST BE REGULATED BY THE DRIVER AND LIMITS OF THE VEHICLE. OUR WARRANTY WILL NOT COVER A TRANSMISSION THAT HAS BEEN OVERHEATED. PLEASE NOTE THAT TRANSMISSION FLUID SHOULD NEVER EXCEED 260 DEGREES OR DAMAGED MAY OCCUR, ALSO SHOULD NOT EXCEED 240 DEGREES FOR ANY EXTENDED PERIOD OF TIME. NORMAL OPERATING TEMPERATURE FOR TRANSMISSION FLUID IS GENERALLY BETWEEN 180 DEGREES AND 220 DEGREES. FACTORS THAT MAY AFFECT TEMPERATURE INCLUDE; ENGINE LOAD, OUTSIDE AIR TEMPERATURE, VEHICLE SPEED, TRAILER SIZE AND WEIGHT, ENGINE COOLING SYSTEMS, MECHANICAL AND ELECTRIC COOLING FANS, ANY FAILURE TO ANY OF THESE SYSTEMS MAY COMPROMISE THE TRANSMISSION AND MUST BE REPAIRED IMMEDIATELY.	LUKE HARRISON	$0.00
2021-03-22	COURTESY INSPECTION (FREE) - TECHNICIAN NOTES, THE PARKING BRAKE DOESN'T HOLD, THERE IS SEVERAL OIL SEEPS ON THE ENGINE, THE AIR FILTER IS VERY DIRTY AND SHOULD BE REPLACED, THE SERPENTINE BELT HAS CRACKING, THE BATTERYIES ARE LEAKING BATTERY ACID, BOTH UPPER BALL JOINTS HAVE SLIGHT HORIZONTAL MOVEMENT, THE SWAY BAR LINK BUSHINGS ARE WEATHER CRACKED, THE FRONT BRAKE PADS ARE AT 8/32", THE REAR BRAKE PADS ARE AT 3/32", THE FUEL FILTER IS DUE BY THE MILES, THE REAR DIFFERENTIAL CHECK PLUG IS SEEPING, THE TRANSMISSION TO BLOCK MOUNTED COOLER LINE IS DRIPPING, THE TRANSMISSION PAN HAS AN AFTERMARKET DRAIN PLUG INSTALLED THAT IS STRIPPED AND LEAKING.	TYLER SPANGLER	$0.00
2021-03-31	TECHNICIAN NOTES, ONCE WE REMOVED THE TRANSMISSION WE FOUND THE REAR MAIN CRANKSHAFT SEAL TO BE SEEPING. TECHNICIAN RECOMMENDS REPLACING THE SEAL WHILE THE TRANSMISSION IS OUT OF THE VEHICLE.	TYLER SPANGLER	$175.10
2021-03-30	TECHNICIAN NOTES, THE TRANSMISSION COOLER LINE GOING FROM THE TRANSMISSION TO THE BLOCK MOUNTED COOLER HAS A DRIPPING LEAK. TECHNICIAN RECOMMENDS REPLACING THE LINE AT THIS TIME IN ORDER TO UPHOLD THE WARRANTY ON THE TRANSMISSION BUILD.	TYLER SPANGLER	$156.61
2021-04-01	TECHNICIAN NOTES, WE WERE ATTEMPTING TO FLUSH THE TRANSMISSION COOLERS AND FOUND THE BLOCK MOUNTED COOLER FLUSHED WITHOUT ISSUES. HOWEVER THE TRANSMISSION COOLER THAT SITS IN FRONT OF THE RADIATOR WAS PLUGGED INTERNALLY AND WOULDN'T ALLOW US TO FLUSH THE UNIT. TECHNICIAN RECOMMENDS REPLACING THE TRANSMISSION COOLER AT THIS TIME TO PREVENT THE TRANSMISSION OVERHEATING.	TYLER SPANGLER	$387.24
Sub-total			$3,748.42
Hazardous Materials Disposal			$48.26
Shop Supplies			$49.11
Sub-total			$3,845.79
Tax ($7.25%)			$271.76
FUEL			$25.00
Total			$4,142.55

Payments

Total Payments To Date			$4,142.55
Balance Remaining			$0.00

View all Payments for this Invoice

KPI's

You have an error in your SQL syntax; check the manual that corresponds to your MariaDB server version for the right syntax to use near '' at line 1You have an error in your SQL syntax; check the manual that corresponds to your MariaDB server version for the right syntax to use near 'and c.CustomerID=v.CustomerID and v.VehicleID=i.VehicleID and i.InvoiceID = ...' at line 1

KPI	Target	Actual	Gap