Not yet Run

Print Quote Print RO Print Invoice

Images

Jobs

Start Date	Description	Technician	Amount
2021-08-19	A. CUSTOMER WOULD LIKE US TO RINSTALL EMISSIONS COMPONENTS ON VEHICLE AND HAVE THE TUNING RETURNED TO STOCK. - UPON REMOVING PARTS TO HAVE THE DPF CLEANED THE DIFFERENTIAL PRESSURE SENSOR, DEF INJECTOR AND TEMP SENSOR WERE DAMAGED DUE TO BEING SEIZED IN PLACE. TECHNICIAN RECOMMENDS REPLACING THESE PARTS WITH GOOD USED PARTS IN ORDER TO HAVE THE EMISSIONS SYSTEM INTACT. AFTER GETTING THE DPF BACK FROM CLEANING WE WERE REMOVING THE EXHAUST IN PLACE, AND FOUND ONE OF THE REAR FLANGES HAD BOLTS MISSING AND SOMEONE HAS WELDED THE EXHAUST FLANGES TOGETHER. WE WERE ABLE TO USE AN OXY TORCH TO CUT THE WELDS AND SEPERATE THE FLANGES. THERE WAS ALSO ONE EXHAUST TEMPERATURE SENSOR THAT HAS A DIFFERENT CONNECTOR ON THE VEHILCE SIDE RATHER THAN THE SENSOR SIDE WE CAN REPLACE THE CONNECTORS WITH A TWO TERMINAL WATERPROOF CONNECTOR. IN ADDITION WE FOUND ALL OF THE CONNECTORS TO HAVE CORROSION, WE HAVE CLEANED THEM AS BEST AS WE CAN USING TERMINAL CLEANING SPRAY AND DIAMOND MALE AND FEMALE TERMINAL CLEANER TOOLS.	JONI WALKER	$1,263.87
2021-08-30	B. TECHNICIAN NOTES, ONCE THE DPF WAS REINSTALLED AND THE ECM WAS RETURNED TO STOCK WE HAD MULTIPUL CHECK ENGINE LIGHT CODES PRESENT. P242D FOR EXHAUST GAS TEMPERATURE SENSOR CIRCUIT HIGH BANK 1 SENSOR 3, P2455 FOR PARTICULATE FILTER PRESSURE SENSOR A CIRCUIT HIGH, P2455 FOR PARTICULATE FILTER PRESSURE SENSOR "A" CIRCUIT HIGH, P2200 FOR NOx SENSOR CIRCUIT (B1S1), P220E FOR NOx SENSOR HEATER CONTROL CIRCUIT RANGE PERFORMANCE (B1S1), AND P0403 FOR EGR "A" CONTROL CIRCUIT OPEN. FOR THE FIRST CODE P242D TECHNICIAN MONITORED THE #3 EGT SENSOR AND FOUND AT AN IDLE IT WAS READING 2500 DEGREES. TECHNICIAN RECOMMENDS REPLACING THE SENSOR BEFORE RECHECKING FOR OTHER POSSIBLE ISSUES. FOR THE SECOND CODE, P2455 WE FOUND COMMON ISSUES WITH THE TERMINALS ON THE PIGTAILS TO BE CORRODED. UPON REINSTALLATION OF THE DPF THE CONNECTOR THE DIFFERENTIAL PRESSURE SENSOR HAD A BURN MARK ON THE PLASTIC OF THE CONNECTOR AS WELL AS EXCESSIVE CORROSION IN THE TERMINALS WE ATTEMPTED TO CLEAN OUT. TECHNICIAN RECOMMENDS REPLACING THE PIGTAIL BEFORE RECHECKING FOR OTHER POSSIBLE ISSUES. FOR THE THIRD AND FOURTH CODES, P2200 AND P220E BOTH ARE AN INDICATION OF THE NOx SENSOR HAVING A FAULT. TECHNICIAN RECOMMENDS REPLACING THE NOx SENSOR BEFORE RECHECKING FOR OTHER POSSIBLE ISSUES. FOR THE FIFTH CODE PRESENT, P0403 TECHNICIAN RECOMMENDS FIXING THE OTHER ISSUES FIRST BEFORE TEST DRIVING THE VEHICLE. IT IS POSSIBLE THE EGR VALVE IS STICKING AND DRIVING THE VEHICLE WITH THE SYSTEM WORKING AGAIN MAY FREE UP THE VALVE. IT IS ALSO POSSIBLE THE VALVE WILL NEED TO BE REPLACED.	TYLER SPANGLER	$766.73
2021-09-01	C. TECHNICIAN NOTES, AFTER FIXING THE SENSOR AND CIRCUIT CODES PREVIOUSLY THE EGR VALVE CODE IS RETURNING INSTANTLY AFTER CLEARING. TECHNICIAN VERIFIED THE EGR VALVE IS GETTING POWER. WE CHECKED RESISTANCE ON THE EGR VALVE AND FOUND IT HAS AN OPEN CIRCUIT WITH NO RESISTANCE. TECHNICIAN RECOMMENDS REPLACING THE EGR VALVE AND APPLICABLE GASKETS.	TYLER SPANGLER	$876.70
2021-08-23	D. DIESEL - OIL CHANGE FORD POWER STROKE - - OIL CHANGE (LUBE, OIL, AND FILTER) SYNTHETIC BLEND OIL USED AND RECOMMENDED SERVICE INTERVAL OF 5,000 MILES.	JONI WALKER	$109.99
2021-08-19	E. A/C EVACUATE AND RECHARGE ADD DIE AND DIAGNOSE LEAK	JONI WALKER	$149.99
2021-09-24	F. EXHAUST FLUID (DEF) 2.5 GAL	TYLER SPANGLER	$11.99
2021-08-19	G. COURTESY INSPECTION (FREE) - TECHNICIAN NOTES, THE LEFT REVERSE LIGHT IS OUT, THE RIGHT PLATE LIGHT IS OUT, THE OIL CHANGE IS DUE IN 43 MILES ACCORDING TO THE DASH, THE TRANSMISSION FLUID IS SLIGHTLY DARK, THE COOLANT WAS LOW IN THE RESERVOIR WITH NO SIGNS OF A LEAK ON THE SYSTEM, THERE IS MULTIPUL ENGINE OIL SEEPS, THE PASSENGER SIDE BATTERY IS WEAK, THE FRONT BRAKE PADS ARE AT 8/32", THE REAR BRAKE PADS ARE AT 10/32", THE FUEL FILTER IS DUE BY THE MILES, THE TRANSFER CASE FLUID IS SLIGHTLY DARK, THE AIR BAG LIGHT IS ON, AND THE SLIP YOKE ON THE REAR DRIVE LINE IS SEEPING AROUND THE CAP ON THE SLIP YOKE.	JONI WALKER	$0.00
2021-09-24	H. TECHNICIAN NOTES, AFTER INSTALLING THE EGR VALVE AND TEST DRIVING THE VEHICLE THE CHECK ENGINE LIGHT CAME ON WITH CODES - P0506, P2073, P2074, P0402, AND P20EE. WE WERE ABLE TO CLEAR THE CODES AND THEY HAVEN'T RETURNED AT THIS TIME. MANY TIMES AFTER THESE SYSTEMS HAVE BEEN TURNED OFF THEY NEED TO HAVE MULTIPUL DRIVE CYCLES BEFORE THE CHECK ENGINE LIGHT WILL STAY OFF. TECHNICIAN RECOMMENDS DRIVING THE VEHICLE BEFORE TRYING TO DIAGNOSE THE CODES SINCE THEY ARE NOT CURRENT AT THIS TIME.	AUSTIN KALLUNKI	$0.00
Sub-total			$3,179.26
Hazardous Materials Disposal			$58.26
Shop Supplies			$59.11
Sub-total			$3,296.63
Tax ($7.25%)			$230.50
FUEL			$35.00
Total			$3,562.13

Payments

Total Payments To Date			$3,562.13
Balance Remaining			$0.00

View all Payments for this Invoice

KPI's

You have an error in your SQL syntax; check the manual that corresponds to your MariaDB server version for the right syntax to use near '' at line 1You have an error in your SQL syntax; check the manual that corresponds to your MariaDB server version for the right syntax to use near 'and c.CustomerID=v.CustomerID and v.VehicleID=i.VehicleID and i.InvoiceID = ...' at line 1

KPI	Target	Actual	Gap